Moderators: ThePagan, TXJEEPER, Xtremjeepn
Go
New
Find
Notify
Tools
Reply
  
-star Rating Rate It!  Login/Join 
Newbie
Picture of jeepcrazed
Posted
i have a 98 jeep tj sport and i was wondering where the thermostat was and is it an easy fix. thanks.
 
Posts: 29 | Location: Winnipeg, MB Canada | Registered: December 22, 2005Reply With QuoteEdit or Delete MessageReport This Post
Grocery Getter
Trail Lubber
Picture of COL Mustard
Posted Hide Post
Fairly easy fix. Look at the top of your radiator and follow the big hose to the engine. Where it attaches at the engine is the thermostat housing. It should also have a smaller heater hose and a temperature sensor attached to it. There are two bolts holding the housing on. For a cleaner job, drain a bit of coolant out of your radiator into a clean bucket from the drain underneath. I find it easier to work with by removing the temp sensor plug and both hoses from the housing and then the two bolts. Once the housing is off, the thermostat should fall right out. pay attention to the direction it is installed. clean off the old gasket and clean all debris out of the housing. install new gasket and thermostat. Tighten 2 bolts and reinstall hoses. Put coolant back in radiator, run engine and check for leaks.


01 Yellow TJ soft top, F/R ARB,4:56,disc brakes, Currie 5x5.5 D60,D44 w/warn hubs, CTM U-joints, Rock Ready 8" Weld Stone Crusher 15" wheels w/OMF beadlocks 35x14.50 SSRs, Bullet Proof bumpers w/tire carrier & jerry can mounts, York air w/2.5gl tank, 4 Piaa 520s, 9500is winch, Turbo City intake with K&N filter,Poweraid spacer, AGR rock ram, ORO U-turn steering Turbo City rock rails, Xenon 6" fenders, IPF Ion crystal head lights, Borla cat back, Kilby dual battery tray w/Optima yellow tops, Genright SC gas tank, Premier Power Welder, Cobra 75 CB, AEV hood, MasterCraft Rubicon seats Front & rear, Off Road Engineering electronic throttle control, bored throttle body and a few other goodies.
 
Posts: 383 | Location: South Jordan, Utah | Registered: May 19, 2002Reply With QuoteEdit or Delete MessageReport This Post
 Previous Topic | Next Topic powered by eve community  
 


© Copyright 2007 Rockcrawler 4x4 and Off-Road Magazine